C4.4 Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Request a Quote
Bore
4.13 in
Displacement
268.5 in
Stroke
5 in
Fuel System
Electronic (adjustable)

Videos not available for this product.

360 View not available for this product.

Product Specs

Engine Specifications

Bore
4.13in
Displacement
268.5in
Stroke
5in
Fuel System
Electronic (adjustable)
Engine Model
C4.4, In-line 4, 4-cycle diesel
Compression Ratio
18.2:1
Governor Type
Adem™A4
Fuel System
Electronic (adjustable)
Bore
4.13in
Displacement
268.5in
Stroke
5in

Generator Set Specifications

Minimum Rating
36 ekW
Maximum Rating
60 ekW
Voltage
208-600 Volts
Frequency
60 Hz
Speed
1800 RPM

Generator Set Configurations

Emissions/Fuel Strategy
U.S. EPA Certified for Stationary Emergency Use Only (Tier 3 Nonroad Equivalent Emission Standards)

Standard/Optional Features

Standard Equipment:

  • Charging System
    • CAT Premium High Output Battery(s) with rack & cables Installed (wet);1000CCA;90amp hr;12V
  • Control System
    • EMCP 4.2
    • Controls include: Run / Auto / Stop Control - Speed Adjust - Engine Cycle Crank - Emergency Stop pushbutton
    • Features include: 12-volt DC operation - Environmental sealed front face - Text alarm/event descriptions
    • Digital indators for: RPM - DC volts - Operating hours, - Oil pressure - Coolant pressure - Volts (L-L & L-N), frequency (Hz) - Amps (per phase & average) - Power Factor (per phase & average) - kW (per phase,average & percent) - kVA (per phase,average & percent) - kVAr (per phase,average & percent) - kW-hr (total) - kVAr-hr (total)
    • Warning / Shutdown with common LED indicators for: -Low Oil pressure - Low coolant temperature alarm (detects jkt water heater failure) - High coolant temperature shutdown
    • Communications: Customer DATA link (Modbus RTU) - RS485 Serial DATA link (terminals only) - 8 programmable digital outputs available - 2 relays pre-programmed - 8 programmable digital inputs available - 2 pre-programmed
  • Circuit Breakers
    • Optional UL/CSA listed mainline breakers
    • Optional Multiple Breakers 100% Rated 3-pole with solid neutral
    • NEMA 1 steel enclosure
    • Electrical stub-up area directly below circuit breaker
  • Cooling System
    • Radiator and cooling fan complete with protective guards
    • Standard ambient temperatues up to 50degC (122degF)
    • 50% coolant antifreeze/corrosion inhibitor
    • Coolant reservoir
  • Generator
    • Insulation system,class H
    • Drip proof generator air intake (NEMA 2,IP23)
    • Electrical design in accordance with BS5000 Part 99,EN61000-6, IEC60034-1,NEMA MG-1.33
    • All electroplated hardware or stainless steel
    • Anticorrosive paint protection
    • High gloss polyurethane paint for durability and scuff resistance
  • Mounting System
    • Heavy-duty fabricated steel base with lifting points
    • Anti-vibration pads to ensure vibration isolaton
    • Complete OSHA guarding
    • Stub-up pipe ready for connection to silencer pipework
    • Flexible fuel lines to base with NPT connections
  • General
    • Warranty per SELF5611

Optional Equipment:

  • Certificates
    • IBC Seismic and Wind Certifications
  • Air Inlet System
    • Cartridge type air filter
  • Charging System
    • NFPA battery charger UL10A 120VAC
  • Circuit Breakers
    • 3-Pole 100% rated
    • Breakers (100% UL rated)
    • Second circuit breaker box
    • Power perminal strips
  • Control Panels
    • NFPA110 bundle includes: FSS low fuel level alarm & indication panel circuitry required when sub-base tank is selected - WSS1 Low Coolant level shut down - WCA1 Low Coolant temperature alarm - PAA1 Panel mounted audible alarm - PBC10NU NFPA Battery Charger - A coolant heater ,remote annunciator or 0.8 power factor test may be required depending on the application
    • Oil temperature guage and sender
    • Audible alarm
    • Ground fault relay
    • Discrete I/O module
    • Remote E-stop button
    • Volt free contacts genset run and common alarm
    • Remote annunciator
    • Protective devices: Low coolant temperature alarm - Low coolant level shutdown - Fuel level reading - Overload shutdown via breaker
  • Cooling System
    • Radiator stone guard
    • Radiator transition flange
  • Enclosures
    • Weatherproof enclosure
    • Sound attenuated enclosure, level 1
    • Sound attenuated enclosure, level 2
    • Panel viewing window
    • External emergency stop
  • Heating Elements
    • Coolant heater
    • Jacket water heater
    • Anti-condensation heater
    • Battery heater
    • Lube oil sump heater
    • Wiring for canopy space heater
  • Exhaust System
    • 10, 25 and 35 dBA silencer systems
    • Overhaed silencer mounting kit
  • Fuel System
    • 209 and 394 gallon sub-base fuel tanks
    • 5 gallon fill containment
    • 5 gallon spill containment
    • Emergency vent pipe
    • Tank riser
  • Generators
    • Permanent magnet generator
  • Mounting System
    • Seismic vibration isolators
  • Tests
    • Generator test report
    • PGS test report @ 1.0 power factor
    • PGS test report @ 0.8 power factor
    • 4 Hour factory test